AD-100m³型空氣干燥發生器使用AD系列干燥空氣發生器進行電力設備安裝、檢修時，不受外界氣候條件變化的影響—即使陰雨季節，也可正常施工。在需隔夜施工時，只需封好各處法蘭，充干燥空氣達到0.02～0.03Mpa即可。大大減少了工作量，達到縮短工期、提高安裝檢修質量的效果。

AD-100m³型空氣干燥發生器 

高效過濾系統。采用“漸密”過濾技術，zui高過濾精度為0.01µm，固體顆粒截留率高達99.99%。一級過濾器過濾精度為µm，二級過濾器過精度為0.1µm，三級過濾器過濾精度為0.01µm。

成品氣露點低。衡量干燥空氣發生器的核心指標為供氣露點，露點越低，代表空氣越干燥。低露點干燥空氣將吸附變壓器內的水份以提高變壓器的絕緣性能。漢儀牌AD-P系列干燥空氣及壓縮干燥、冷凍干燥及吸附干燥于一體并采用多級過濾系統。由于采用了我公司獨自研發的“強力復合分子吸附劑”，不管空氣中的含水量有多少，成品氣的露點都將迅速降低到-70℃以下。

AD-100m³型空氣干燥發生器 脫水原理

空氣在空氣壓縮機的作用下，體積被壓縮為原來的1/8，此時空氣中的水蒸氣達到飽和狀態，大部分飽和水蒸氣在儲氣罐內凝結成液態水并沉積于儲氣罐底；部分隨壓縮空氣流動的小水珠及顆粒在經過一級過濾器時被攔截下來；壓縮空氣隨后進入冷凍機，壓縮空氣在冷凍機內溫度降為4℃，水蒸氣再次大量達到飽和狀態并凝結成液態水沉積在冷凍機內；壓縮空氣經過過濾精度0.1µm及0.01µm的精密過濾器后，壓縮空氣的大氣露點約為-22℃；進入吸附塔后，空氣中的水分子被強力復合分子吸附劑吸附住，其他空氣成份排出干燥空氣發生器，經過吸附后的空氣露點低于-70℃，相當于每立方米空氣含水量為0.005克（20℃時空氣中的飽和含水量為17.3克）。